Product ID:AEROSHELL/ROYCO TURBINE OIL 560
MSDS Date:07/18/1995
FSC:9150
NIIN:01-439-2070
MSDS Number: CFZDR

ROYAL LUBRICANTS COMPANY INC.

MERRY LN
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411/800-424-9300(CHEMTREC)

Info Phone: 201-887-7410

Cage: 07950

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

SYNTHETIC ESTER/PENTAERYTHRITOL ESTERS

CAS: 68424-31-7

Fraction By Weight: 0 - >90%

SYNTHETIC ESTER/FATTY ACIDS, C5-9, MIXED ESTERS

CAS: 68424-33-9

Fraction By Weight: 0 - >90%

OCTYLATED N-PHENYL-1-NAPHTHYLAMINE

CAS: 68259-36-9

Fraction By Weight: <2%

P,P'-DIOCTYLDIPHENYLAMINE

CAS: 101-67-7

RTECS: JJ8850000

Fraction By Weight: <2%

TRICRESYL PHOSPHATE (MIXED ISOMERS)

CAS: 1330-78-5

RTECS: TD0175000

Fraction By Weight: 1%

MINOR ADDITIVES

Fraction By Weight: <1%

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, NERVE & GI
TRACT. ACUTE- LUBRICATING OILS ARE CONSIDERED NO MORE THAN
MINIMALLY IRRITATING TO EYES & SKIN. INJECTION INTO SKIN CAUSES
NECROSIS. INHALATION OF VAPOR (HOT OIL)/M IST MAY CAUSE MILD
IRRITATION & DELAYEDNEUROTOXICITY. COULD BE TOXIC IF
SWALLOWED/ABSORBED THROUGH SKIN. CHRONIC- UNK.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, TISSUE DAMAGE,
NAUSEA, VOMITING, HEADACHE
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED NERVE OR RESPIRATORY FUNCTION
MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES. HOLD EYELIDS OPEN. SKIN:WIPE OFF EXCESS. WASH SKIN WITH
SOAP & WATER. I F INJECTED UNDER SKIN, CONTACT A PHYSICIAN PROMPTLY
TO PREVENT SERIOUS INJURY. ORAL:IF CONSCIOUS, DRINK NO MORE THAN 2
GLASSES OF WATER & INDUCE VOMITING. GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:500F,260C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. PROVIDE ADEQUATE
VENTILATION. REMOVE SPILL WITH VACUUM TRUCK OR PUMP TO
STORAGE/SALAVAGE VESSELS. SOAK UP RESIDUE WITH CLAY/SAND. PREVENT
RUN-OFF TO ENTER SEWERS OR WATERWAY S. REPORT SPILLS AS REQUIRED TO
AUTHORITIES.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE,
AWAY FROM OXIDIZERS. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES. MINIMIZE SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRES SURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:ADEQUATE
Protective Gloves:RUBBER
Eye Protection:GOGGLES/SAFETY GLASSES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF VICTIM IS A CHILD, GIVE NO MORE THAN 1 GLASS OF
WATER AND 15 ML (1 TABLESPOON) SYRUP OF IPECAC. IF SYMPTOMS SUCH AS
LOSS OF GAG REFLEX, CONVULSION OR UNCONSCIOUSNESS OCCUR BEFORE
EMESIS, GASTRIC LAVAGE SHOULD BE CONSIDERED FOLLOWING INTUBATION
WITH A CUFFED ENDOTRACHEAL TUBE.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:0.99
Viscosity:28 CST @ 100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, FLAME
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER
SECTION 311 OF THE CLEAN WATER ACT. SPILLS THAT CAUSE A SHEEN MUST
BE REPORTED TO THE NAT IONAL RESPONSE CENTER, 800-424-8802.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.